1. Identification
| Product identifier | JH WALL PAINTS — MINERAL PRIME |
|---|---|
| Product form | Mixture |
| Use of the substance / mixture | Silicate-based primer for interior and exterior use |
| Uses advised against | All other uses are not recommended |
| Company name | JH Wall Paints |
| Address | 28686 Airoso Street, Rancho Mission Viejo, CA 92694 |
| Telephone | 1-833-925-5724 |
| Emergency phone number | In US and Canada: 1-800-535-5053 (INFOTRAC) |
| SDS number | 0503-0103_US |
2. Hazard(s) Identification
Classification of the chemical — 29 CFR Part 1910.1200
| GHS US classification | Not classified |
|---|---|
| Signal word | None |
| Pictogram | None |
| Hazard statements | None |
| Precautionary statements | None required |
| Label elements | No labeling applicable |
| Unknown acute toxicity (GHS US) | Not applicable |
Hazards not otherwise classified
Alkaline product. Avoid contact with skin and eyes.
3. Composition / Information on Ingredients
Mixtures. Chemical characterization: aqueous priming on the basis of potassium silicate and a copolymer synthetic resin dispersion.
Hazardous components
| CAS No. | Component | Quantity | Classification |
|---|---|---|---|
| 13463-67-7 | Titanium dioxide, in powder form containing 1% or more of particles with aerodynamic diameter ≤ 10 µm | 2.5 – 10 % | Carc. 2, H351 |
| 1312-76-1 | Potassium salt | ≤ 2.5 % | Skin Irrit. 2, H315 Eye Irrit. 2, H319 |
The classification as a carcinogen by inhalation applies only to mixtures in powder form containing 1% or more of titanium dioxide which is in the form of, or incorporated in, particles with aerodynamic diameter ≤ 10 µm.
Full text of hazard classes and H-statements: see section 16.
4. First-Aid Measures
| General information | No specific measures are necessary. |
|---|---|
| After inhalation | Remove the person to fresh air and keep comfortable for breathing. |
| After contact with skin | Wash off immediately with soap and plenty of water. Do not use solvents or thinners. Get medical advice if skin irritation persists. |
| After contact with eyes | Rinse immediately with plenty of water, also under the eyelids, for at least 15 minutes. |
| After ingestion | Rinse out mouth thoroughly with water. Do NOT induce vomiting. Call a physician immediately. |
| Most important symptoms and effects, both acute and delayed | No additional information available. |
| Immediate medical attention and special treatment needed | Treat symptomatically. |
5. Fire-Fighting Measures
| Suitable extinguishing media | The product itself does not burn. Fire-extinguishing activities according to the surroundings. |
|---|---|
| Specific hazards arising from the chemical | Hazardous decomposition products in case of fire: carbon oxides (CO, CO₂), acrylic monomers. |
| Protection during firefighting | Do not attempt to take action without suitable protective equipment. Self-contained breathing apparatus. Complete protective clothing. |
| Other information | Fire residues and contaminated firefighting water must be disposed of in accordance with local regulations. |
6. Accidental Release Measures
| General measures | Avoid contact with skin, eyes and clothing. A respirator must be worn if exposed to dust. Spills of this product present a serious slipping hazard. |
|---|---|
| For non-emergency personnel | Ventilate the spillage area. Ensure adequate air ventilation. |
| For emergency responders | Do not attempt to take action without suitable protective equipment. For further information refer to section 8. |
| Environmental precautions | Avoid release to the environment. |
| Methods and material for containment and cleaning up | Take up the liquid spill into absorbent material such as sand or sawdust. Shovel into a suitable, closed container for disposal. Clean the contaminated surface thoroughly. Dispose of materials or solid residues at an authorized site. |
| Reference to other sections | Refer to the protective measures listed in sections 7 and 8. For disposal, refer to section 13. |
7. Handling and Storage
| Precautions for safe handling | Ensure good ventilation of the work station. Wear personal protective equipment. Keep the container tightly closed. |
|---|---|
| Hygiene measures | Do not eat, drink or smoke when using this product. Always wash hands after handling the product. |
| Storage conditions | Store in a well-ventilated place. Keep cool. Keep only in the original container. |
| Incompatible materials | Acids. |
| Storage area | Keep out of frost. Store away from heat. Keep out of direct sunlight. |
8. Exposure Controls / Personal Protection
Exposure limits
| CAS No. | Substance | Value | Category | Origin |
|---|---|---|---|---|
| 13463-67-7 | Titanium dioxide | 10 mg/m³ | TWA (8 h) | ACGIH TLV |
| 13463-67-7 | Titanium dioxide, total dust | 15 mg/m³ | TWA (8 h) | OSHA PEL |
| 1312-76-1 | Potassium salt | No additional information available | ||
ACGIH TLV basis: lower respiratory tract irritation. Notation A4 — not classifiable as a human carcinogen. Regulatory references: ACGIH 2021; OSHA Annotated Table Z-1.
Exposure controls
| Appropriate engineering controls | Ensure good ventilation of the work station. |
|---|---|
| Environmental exposure controls | Avoid release to the environment. |
| Protective and hygiene measures | Wash hands immediately after handling the product. Do not eat, drink or smoke in areas where the product is used. |
| Eye / face protection | Safety goggles recommended during refilling. |
| Hand protection | Protective gloves. Suitable materials: butyl rubber, 0.7 mm; natural rubber, 0.6 mm; nitrile impregnated cotton gloves, polyvinylchloride (PVC) or polyethylene, 0.5 mm. Permeation time greater than 480 minutes in all cases. |
| Skin / body protection | Protective clothing. |
| Respiratory protection | Where aerosol or mist is formed, wear a NIOSH-approved N95 or equivalent particulate respirator. |
Choosing the proper glove depends not only on the type of material but also on other quality features, which differ between manufacturers. The exact breakthrough time must be established by the manufacturer of the protective gloves and observed.
9. Physical and Chemical Properties
| Physical state | Liquid |
|---|---|
| Appearance | Pasty |
| Color | White |
| Odor | Soft |
| Odor threshold | n.d. |
| pH value | ≈ 10.4 * |
| Volatile organic compounds (VOC) | 0 g |
| Melting point / freezing point | n.d. |
| Boiling point | n.d. |
| Flash point | n.d. |
| Relative evaporation rate (butyl acetate = 1) | n.d. |
| Flammability (solid, gas) | n.a. |
| Vapor pressure | ≈ 23 hPa |
| Relative vapor density at 20 °C | n.d. |
| Relative density | n.d. |
| Density | 1.4 – 1.6 g/cm³ * |
| Solubility | Miscible with water |
| Log Pow | n.d. |
| Auto-ignition temperature | Not self-igniting |
| Decomposition temperature | n.d. |
| Viscosity, kinematic | n.d. |
| Viscosity, dynamic | 1700 – 2000 mPa·s * |
| Explosion limits | n.d. |
| Explosive properties | The product is not explosive. |
| Oxidizing properties | n.d. |
* The values are for freshly produced material and may change with time.
10. Stability and Reactivity
| Reactivity | The product is non-reactive under normal conditions of use, storage and transport. |
|---|---|
| Chemical stability | Stable under normal conditions. |
| Possibility of hazardous reactions | No dangerous reactions known under normal conditions of use. |
| Conditions to avoid | None under recommended storage and handling conditions. See section 7. |
| Incompatible materials | Oxidizing agents. Acids. |
| Hazardous decomposition products | Under normal conditions of storage and use, hazardous decomposition products should not be produced. Thermal decomposition generates carbon oxides (CO, CO₂) and silicon dioxide. |
11. Toxicological Information
| Acute toxicity, oral | Not classified |
|---|---|
| Acute toxicity, dermal | Not classified |
| Acute toxicity, inhalation | Not classified |
| Skin corrosion / irritation | Not classified. pH ≈ 10.4 |
| Serious eye damage / irritation | Not classified. pH ≈ 10.4 |
| Respiratory or skin sensitization | Not classified |
| Germ cell mutagenicity | Not classified |
| Carcinogenicity | Not classified. Titanium dioxide (13463-67-7): IARC group 2B — possibly carcinogenic to humans. |
| Reproductive toxicity | Not classified |
| STOT — single exposure | Not classified |
| STOT — repeated exposure | Not classified |
| Aspiration hazard | Not classified |
12. Ecological Information
| Ecology — general | The product is not considered harmful to aquatic organisms or to cause long-term adverse effects in the environment. |
|---|---|
| Persistence and degradability | No additional information available. |
| Bioaccumulative potential | No additional information available. |
| Mobility in soil | No additional information available. |
| Other adverse effects | Avoid release to the environment. No ecotoxicological data about this product are known. The product does not contain organically bound halogens which could lead to AOX values. |
13. Disposal Considerations
| Waste treatment methods | Dispose of contents and container in accordance with the licensed collector's sorting instructions. Must not be disposed of together with household garbage. |
|---|---|
| Sewage disposal recommendations | Do not discharge into drains. |
| Additional information | Clean using water and a detergent. |
14. Transport Information
| US DOT 49 CFR 172.101 | No data available. |
|---|---|
| Transport of Dangerous Goods (TDG) | No data available. |
| Marine transport (IMDG) | No data available. |
| Air transport (ICAO-TI / IATA-DGR) | No data available. |
| Special precautions for user | No data available. |
15. Regulatory Information
| National inventory — TSCA | All components of this product are present and listed as Active on the United States Environmental Protection Agency Toxic Substances Control Act (TSCA) inventory. |
|---|---|
| SARA Section 313 | This product or mixture is not known to contain a toxic chemical or chemicals in excess of the applicable de minimis concentration as specified in 40 CFR §372.38(a), subject to the reporting requirements of section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part 372. |
| Canada — DSL | Titanium dioxide (13463-67-7) and potassium salt (1312-76-1) are listed on the Canadian Domestic Substances List. |
| International listings | Titanium dioxide (13463-67-7) is listed on IARC. Titanium dioxide and potassium salt are listed on INSQ, the Mexican National Inventory of Chemical Substances. |
| California Proposition 65 | This product contains titanium dioxide, which is listed under Proposition 65 only as airborne, unbound particles of respirable size. No such exposure is expected from normal use of the product in liquid form. |
| US state regulations | Titanium dioxide (13463-67-7): U.S. New Jersey Right to Know Hazardous Substance List; U.S. Pennsylvania Right to Know List. |
16. Other Information
| Revision number | 13.1 |
|---|---|
| Revision date | 28 September 2026 |
| Supersedes | Version 13.0, 24 August 2021 |
| Department issuing SDS | JH Wall Paints, Product safety department |
Full text of H-statements
| H315 | Causes skin irritation |
|---|---|
| H319 | Causes serious eye irritation |
| H351 | Suspected of causing cancer |
Other information
The data in sections 4 to 8 and 10 to 12 do not in all cases refer to the use and the regular employing of the product — for that, consult the information on use and on the product — but to the liberation of major amounts in the case of accidents and irregularities. The information describes exclusively the safety requirements for the product and is based on the present level of our knowledge.
Abbreviations and acronyms
ACGIH American Conference of Governmental Industrial Hygienists · AOX Adsorbable organically bound halogens · ATE Acute toxicity estimate · CAS Chemical Abstract Service · DOT Department of Transportation · DSL Domestic Substances List · GHS Globally Harmonized System of Classification and Labeling of Chemicals · IARC International Agency for Research on Cancer · IATA/ICAO International Air Transport Association / International Civil Aviation Organization · IMDG International Maritime Code for Dangerous Goods · INSQ Mexican National Inventory of Chemical Substances · OEL Occupational exposure limit · OSHA Occupational Safety and Health Administration · PEL Permissible exposure limit · RTK Right to Know · SARA Superfund Amendments and Reauthorization Act · SDS Safety Data Sheet · STOT Specific target organ toxicity · TDG Transport of Dangerous Goods · TLV Threshold limit value · TSCA Toxic Substances Control Act · TWA Time-weighted average · VOC Volatile organic compounds · n.a. not applicable · n.d. not determined